Product ID:D-A SUPER MOLY PLEX 1
MSDS Date:11/19/1985
FSC:9150
NIIN:01-015-1542
MSDS Number: BJQHF

D-A LUBRICANT CO INC SUB OF PREMIER INDUSTRIAL

1340 W 29TH ST
INDIANAPOLIS, IN 46208-4943
US

Emergency Phone: 317-923-5321

Info Phone: 317-923-5321

Cage: 30719

D-A LUBRICANT CO INC SUB OF PREMIER INDUSTRIAL

INDIANAPOLIS, IN 46208-4943 US

Telephone: 317-923-5321/216-391-8300 OTHER HRS

Cage: 30719

BARIUM SULFONATE

CAS: 61790-48-5

RTECS: CR0700000

OSHA PEL 0.5 MG/M3

ACGIH TLV: 0.5 MG/M3

"NOT HAZARDOUS"

Fraction By Weight: TO 100%

LD50 LC50 Mixture:LD50 (ORAL RAT) IS NOT AVAILABLE
Routes of Entry: Inhalation:NO Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:MAY BE MILDLY IRRITATING. RELEASE
DURING HIGH PRESSURE USAGE MAY RESULT IN INJECTION OF OIL INTO THE
SKIN CAUSING LOCAL NECROSIS. HIGH TEMPERATURE VAPORS MAY IRRITATE
RESPIRATORY TRACT. LOW LEVEL OF T OXICITY(INGESTED). CHRONIC
OVEREXPOSUREMAY CAUSE SKIN DISORDERS, DERMATITIS.
Explanation of Carcinogenicity:NONE OF THE COMPOUNDS IN THIS PRODUCT IS
LISTED BY IARC, NTP, OR OSHA AS A CARCINOGEN.
Effects of Overexposure:EYE:POSSIBLE IRRITATION. SKIN:POSSIBLE
IRRITATION, DERMATITIS WITH CHRONIC EXPOSURE. INHALED:UNLIKELY
EXPOSURE. INGESTED:G/I IRRITATION, LOW TOXICITY.
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN DISORDERS MAY BE
AGGRAVATED BY EXPOSURE TO THIS PRODUCT.

First Aid:EYE: FLUSH WITH WATER FOR 15 MINUTES WHILE HOLDING EYELIDS
OPEN. GET MEDICAL ATTENTION. SKIN: WASH WITH SOAP & WATER/WATERLESS
CLEANER. REMOVE CONTAMINATED CLOTHING AND LAUNDER BEFORE REUSE. IF
IRRITA TION PERSISTS SEE A DOCTOR. INHALED:REMOVE TO FRESH AIR.
GIVE OXYGEN IF BREATHING IS DIFFICULT AND GET MEDICAL CARE.
INGESTION: DO NOT INDUCE VOMITING. IN GENERAL, NO TREATMENT
REQUIRED. SEE DOCTOR.

Flash Point Method:COC
Flash Point:374F,190C
Extinguishing Media:USE CARBON DIOXIDE, FOAM, DRY CHEMICAL, OR WATER
FOG. WATER, ESPECIALLY STREAM, MAY CAUSE FROTHING.
Fire Fighting Procedures:WEAR FIRE FIGHTING PROTECTIVE EQUIPMENT AND A
FULL FACED SELF CONTAINED BREATHING APPARATUS. COOL FIRE EXPOSED
CONTAINERS WITH WATER SPRAY. CONTAIN RUNOFF.
Unusual Fire/Explosion Hazard:COMBUSTION OR HEAT OF FIRE MAY PRODUCE
HAZARDOUS DECOMPOSITION PRODUCTS AND VAPORS.

Spill Release Procedures:SCOOP UP EXCESS GREASE. CLEAN AREA WITH
APPROPRIATE CLEANER.
Neutralizing Agent:NONE.

Handling and Storage Precautions:STORE IN A COOL, DRY PLACE WITH
ADEQUATE VENTILATION. KEEP CONTAINERS TIGHTLY CLOSED WHEN NOT IN
USE. KEEP AWAY FROM OPEN FLAMES & HIGH TEMPERATURES.
Other Precautions:'EMPTY' CONTAINERS MAY CONTAIN RESIDUE OR VAPOR.
TREAT THEM WITH THE RESPECT DUE FULL ONES. DO NOT CUT,WELD,ETC. ON
THEM.

Respiratory Protection:RESPIRATORY PROTECTION WILL NOT NORMALLY BE
REQUIRED. IF VENTILATION DOES NOT MAINTAIN INHALATION EXPOSURES
BELOW PEL(TLV), USE NIOSH/MSHA APPROVED RESPIRATORS AS PER CURRENT
29 CFR 1910.134, INSTRUCT IONS/WARNINGS.
Ventilation:NORMAL ROOM VENTILATION IS NORMALLY SUFFICIENT.
Protective Gloves:NEOPRENE RUBBER AS REQUIRED.
Eye Protection:SAFETY GLASSES RECOMMENDED.
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER.
INDUSTRIAL-TYPE WORK CLOTHING AND APRON AS REQUIRED BY TASK AT
HAND.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES.
Supplemental Safety and Health
MSDS RECEIVED BY NAVY 23NOV86. THERE IS NO EVIDENCE THAT DGSC HAS
PURCHASED THIS NSN FROM THIS VENDOR PRIOR TO THE DATE 15MAR91.

HCC:V6
Spec Gravity:0.95
pH:UNKNON
Solubility in Water:NEGLIGIBLE
Appearance and Odor:GRAY SEMI-SOLID GREASE, OIL ODOR
Percent Volatiles by Volume:UNKNON

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:EXTREMELY HIGH TEMPERATURES
Hazardous Decomposition Products:COMBUSTION WILL PRODUCE A MIXTURE OF
AIRBORNE SOLID, LIQUID PARTICULATES AND GASES (CARBON MONOXIDE &
CARBON DIOXIDE).

Waste Disposal Methods:DISPOSE OF IN AN APPROPRIATE DISPOSAL FACILITY
I/A/W FEDERAL,STATE,LOCAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.